Differences

This shows you the differences between two versions of the page.

--- equipment:vacuum:balzers:turbo [2013/08/10 23:58] – [TCP121] mcmaster
+++ equipment:vacuum:balzers:turbo [2025/08/04 21:23] (current) – external edit 127.0.0.1
@@ Line 26: / Line 26: @@
 ====== TCP121 ======
+Switches:
+  * S9 (left): standby (operate at 66% full speed)
+  * S2 (middle): heating, turbo pump
+  * S1 (right): power.  Reset by holding power off for 2 seconds
 Connectors:
@@ Line 39: / Line 44: @@
 Fuses:
 ^ Fuse ^ Rating ^ Purpose ^
-| F1 | 2.5A |  |
+| F1 | 2.5A | Drive electronics |
-| F2 | 0.2A |  |
+| F2 | 0.2A | Vent valve |
-| F3 | 2.5A |  |
+| F3 | 2.5A | Heater |
-| F4 | 0.5A |  |
+| F4 | 0.5A | Cooling |
-====== Station controllers ======
+====== Station controllers ======
-Above:
+Above: TCP303
 There are also some accessories that allow monitoring pump coolant, controlling vent valves, and other things.
@@ Line 70: / Line 75: @@
 ==== Large plug (16 pin) ====
-XXX: diagram is a little iffy, probably disassemble to confirm this
 Mains to X4 [TCP121 op inst, fig 10]:
-^ Purpose ^ Pin ^
+^ Purpose ^ Pin ^ 120V wire color ^
-| Ground | A8 |
+| Ground (PE / protective earth) | A8 | green |
-| Neutral | A2 |
+| Neutral (N) | A2 | white |
-| Hot | B2 |
+| Hot (L / live) | B2 | black |
-| Jumper | A1-B1 |
+| Jumper | A1-B1 | N/A |
+Confirmed some of these by comparing schematics (which is somewhat hard to read) to pinout by pressing power switch
@@ Line 86: / Line 91: @@
 ==== TCP120/121 to TPH/TPU 060, 240, 330 ====
-X5 (controller) to X8 (pump) [TCP121 op inst, fig 22]:
+X5 (controller) to X8 (pump) [TCP121 op inst, fig 22].  Verified on "3m PM 011 232-X" cable
 ^ Signal ^ TPU/TPH pump ^ TCP controller ^
-|  | S | B8 |
+|  | A | A5 |
-|  | V | A8 |
+|  | B | A4 |
-|  | P | B7 |
+|  | C | A3 |
-|  | N | A7 |
+|  | D | A2 |
+|  | E | A1 |
 |  | F | B6 |
-|  | L | B1 |
+|  | G | B5 |
 |  | H | B4 |
-|  | M | A6 |
 |  | J | B3 |
 |  | K | B2 |
-|  | G | B5 |
+|  | L | B1 |
+|  | M | A6 |
+|  | N | A7 |
+|  | P | B7 |
 |  | R | A1 |
-|  | E | A1 |
+|  | S | B8 |
 |  | T | A2 |
-|  | D | A2 |
 |  | U | A3 |
-|  | C | A3 |
+|  | V | A8 |
-|  | B | A4 |
-|  | A | A5 |
+==== PM 441018-X ====
+Took the connector off of it to make above, pinned out by JM
+| A | a5 |
+| B | a4 |
+| C | a3 |
+| D | a2 |
+| E | a1 |
+| F | b6 |
+| G | a5 |
+| H | a4 |
+| J | a3 |
+| K | a2 |
+| L | a1 |
+| N | a6 |
+| M | N/C |
+| P | N/C |
+| R | N/C |
+| S | N/C |
+| T | N/C |
+| U | N/C |
+| V | N/C |
 ====== History ======